Forum for Science, Industry and Business

Sponsored by:     3M 
Search our Site:

 

How do rotor blades deform in wind gusts?

17.02.2020

In the research project TurbuMetric, scientists from the Jade University of Applied Sciences, the University of Oldenburg and the University of Applied Sciences Emden/Leer are investigating how wind turbines deform during turbulent inflow conditions.

In the research project TurbuMetric, scientists from the Jade University of Applied Sciences, the University of Oldenburg and the University of Applied Sciences Emden/Leer are investigating how wind turbines deform during turbulent inflow conditions.


Flow field over the rotor blade of a model wind turbine. The circle marks the stall, which is the point where the flow starts to detach

Graphic: T. Wester, ForWind


Experimental setup for determining the flow around a rotating blade of the model wind turbine

Photo: J. Puczylowski, ForWind

"The aim of our project is to develop measurement methods that show the deformation of the rotor blades while simultaneously measuring the wind field," says project leader Prof. Dr. Thomas Luhmann from the Jade University.

"This knowledge will help to improve strategies for reducing loads and extending the service life of the rotor blades or to design new blades that operate well even in turbulent flows". There are already findings on the behavior of rotor blades in normal wind, but no suitable methods are available yet for measuring the behavior in extreme gusty wind situations.

First measurements in the wind tunnel

The scientists have now carried out first experimental tests in the large wind tunnel of the Center for Wind Energy Research (ForWind) at the Institute of Physics at the University of Oldenburg.

This large research device, which is unique in its dimensions and characteristics, allows the researchers to generate turbulence in a controlled way and thus study realistic wind fields and their interaction with wind turbines.

For the measurements the scientists use a model wind turbine with rotor blades of 90 centimeters in length – about 70 times smaller than in reality. The blades run at 600 rotations per minute, so that the tip of the blade reaches a speed of 57 meters per second.

"We therefore have to develop a highly dynamic measuring method that covers the entire surface of the rotor blade and works in a non-contact way so that the measurements are not affected," explains Luhmann.

Make tiny particles visible and detect them

In order to be able to measure turbulent flow and deformation of the rotor blades simultaneously, two methods are combined: The Particle Image Velocimetry (PIV) method and photogrammetric measurements.

With the PIV method, a laser makes tiny particles visible, which are added to the air. High-speed cameras record the movements of the passing particles and the change of their positions from one image to the next is used to calculate flow direction and velocity.

Each camera takes up to 12,000 images per second, which results in a very high temporal and spatial resolution. "Of particular interest is, when and how the flow detaches from the rotating blade and which wind situations lead to the largest impacts and thus to the greatest dynamic loads on the components of the wind turbine," explains Dr. Gerd Gülker, who is leading the sub-project at ForWind.

The PIV method is combined with photogrammetric measurements. Four high-speed cameras observe the entire wind rotor and capture 200 images per second. "From the recorded image data, we can derive 3D point clouds and determine their deformations," explains Simon Nietiedt, researcher at the Jade University.

"The result provides data for the entire surface of the rotor blades and is highly accurate – despite the high dynamics of the measured object". The scientists face the challenge to combine both systems in such a way that all data is represented in one system in a temporally and geometrically correct way.

About the project

The research project "TurbuMetric – Optical 3D measurement techniques for the acquisition of dynamic fluid-structure interactions in turbulent wind environments" is a joint project of the Jade University of Applied Sciences, the University of Oldenburg and the University of Applied Sciences Emden/Leer. Starting in 2018 it is granted for three years by the Lower Saxony Ministry of Science and funded by the European Regional Development Fund (EFRE) with around 1.3 million euros.

Wissenschaftliche Ansprechpartner:

Prof. Dr. Thomas Luhmann, luhmann@jade-hs.de, 0441 7708 - 3172
Dr. Gerd Gülker, gerd.guelker@uol.de, 0441 798 - 3511

Katrin Keller | idw - Informationsdienst Wissenschaft
Further information:
http://www.jade-hs.de

Further reports about: rotor blades tiny particles wind tunnel wind turbine wind turbines

More articles from Physics and Astronomy:

nachricht Belle II yields the first results: In search of the Z′ boson
06.04.2020 | Max-Planck-Institut für Physik

nachricht Scientists see energy gap modulations in a cuprate superconductor
02.04.2020 | DOE/Brookhaven National Laboratory

All articles from Physics and Astronomy >>>

The most recent press releases about innovation >>>

Die letzten 5 Focus-News des innovations-reports im Überblick:

Im Focus: When ions rattle their cage

Electrolytes play a key role in many areas: They are crucial for the storage of energy in our body as well as in batteries. In order to release energy, ions - charged atoms - must move in a liquid such as water. Until now the precise mechanism by which they move through the atoms and molecules of the electrolyte has, however, remained largely unknown. Scientists at the Max Planck Institute for Polymer Research have now shown that the electrical resistance of an electrolyte, which is determined by the motion of ions, can be traced back to microscopic vibrations of these dissolved ions.

In chemistry, common table salt is also known as sodium chloride. If this salt is dissolved in water, sodium and chloride atoms dissolve as positively or...

Im Focus: Harnessing the rain for hydrovoltaics

Drops of water falling on or sliding over surfaces may leave behind traces of electrical charge, causing the drops to charge themselves. Scientists at the Max Planck Institute for Polymer Research (MPI-P) in Mainz have now begun a detailed investigation into this phenomenon that accompanies us in every-day life. They developed a method to quantify the charge generation and additionally created a theoretical model to aid understanding. According to the scientists, the observed effect could be a source of generated power and an important building block for understanding frictional electricity.

Water drops sliding over non-conducting surfaces can be found everywhere in our lives: From the dripping of a coffee machine, to a rinse in the shower, to an...

Im Focus: A sensational discovery: Traces of rainforests in West Antarctica

90 million-year-old forest soil provides unexpected evidence for exceptionally warm climate near the South Pole in the Cretaceous

An international team of researchers led by geoscientists from the Alfred Wegener Institute, Helmholtz Centre for Polar and Marine Research (AWI) have now...

Im Focus: Blocking the Iron Transport Could Stop Tuberculosis

The bacteria that cause tuberculosis need iron to survive. Researchers at the University of Zurich have now solved the first detailed structure of the transport protein responsible for the iron supply. When the iron transport into the bacteria is inhibited, the pathogen can no longer grow. This opens novel ways to develop targeted tuberculosis drugs.

One of the most devastating pathogens that lives inside human cells is Mycobacterium tuberculosis, the bacillus that causes tuberculosis. According to the...

Im Focus: Physicist from Hannover Develops New Photon Source for Tap-proof Communication

An international team with the participation of Prof. Dr. Michael Kues from the Cluster of Excellence PhoenixD at Leibniz University Hannover has developed a new method for generating quantum-entangled photons in a spectral range of light that was previously inaccessible. The discovery can make the encryption of satellite-based communications much more secure in the future.

A 15-member research team from the UK, Germany and Japan has developed a new method for generating and detecting quantum-entangled photons at a wavelength of...

All Focus news of the innovation-report >>>

Anzeige

Anzeige

VideoLinks
Industry & Economy
Event News

International Coral Reef Symposium in Bremen Postponed by a Year

06.04.2020 | Event News

13th AKL – International Laser Technology Congress: May 4–6, 2022 in Aachen – Laser Technology Live already this year!

02.04.2020 | Event News

“4th Hybrid Materials and Structures 2020” takes place over the internet

26.03.2020 | Event News

 
Latest News

TU Dresden chemists develop noble metal aerogels for electrochemical hydrogen production and other applications

06.04.2020 | Life Sciences

Lade-PV Project Begins: Vehicle-integrated PV for Electrical Commercial Vehicles

06.04.2020 | Power and Electrical Engineering

Lack of Knowledge and Uncertainty about Algorithms in Online Services

06.04.2020 | Social Sciences

VideoLinks
Science & Research
Overview of more VideoLinks >>>