Dried distiller's grains can help produce more beef

After a summer and fall feeding study done with both heifers and steers, Dr. Jim MacDonald, Experiment Station beef nutritionist, said he believes this by-product of ethanol production will be useful in more than just feedlot or dairy operations.

In the next few years, an additional 200 to 600 million gallons of ethanol are expected to be produced in the High Plains, MacDonald said. Production will utilize up to 214 million bushels of corn or sorghum and result in 1.71 million tons of distiller's grains.

“A majority will likely be utilized by feedyards and dairies, but due to the sheer increase in availability, there should be opportunities for cow/calf and stocker operations to use it as well,” he said.

The most promising opportunity may be in the situation where lightweight calves are held for a couple of months before they go onto wheat, MacDonald said.

The summer grazing study using heifers averaging 600 pounds compared feeding 3 pounds of dried distiller's grain per head per day, or approximately 0.5 percent of the animal's body weight, to no supplement, MacDonald said.

Results showed an improvement in gain of a quarter of a pound per head per day over the control calves, he said.

In the fall dormant range study, steers weighing approximately 400 pounds were compared at unsupplemented, 1-pound, 2-pound and 3-pound per head per day rates, MacDonald said.

Gain improved from just over one-half pound per head per day at the 1-pound rate to 1.75 pound per head per day at the highest level of supplementation, he said.

“However, the effect was quadratic in that the more you supplemented, the incremental gain was lower,” MacDonald said. “In other words, at the 1-pound rate, the efficiency of gain was about 50 percent, where at the highest rate, it was 40 percent.”

During the summer trial, the efficiency was only about 10 percent, he said, because both sets of animals were eating well on grass and the supplementation did not make as big a difference..

“So supplementation is more efficient on dormant range, as you would expect,” MacDonald said.

The economics of supplementing with distiller's grains will depend on the cost of the product compared to the value of gain, he said.

MacDonald paid $118 per ton for the distiller's grains, which equated to a $12.50 per head investment for $18.80 per head in return over the 63 days the heifers were fed.

As corn prices have risen over the past month or so, so has that of distiller's grain, he said. The same scenario now would have the producer paying $175 per ton, which would result in a $18.96 per head investment for a $16.20 per head return.

“Producers need to run the economics in their situation to see if it is a good fit,” he said.

The 56-day fall trial, using the $175 per ton rate for the distiller's grains, resulted in at $16.33 per head investment at the highest level of supplementation, MacDonald said. That investment was worth $68.25 per head.

“The economics would say in the fall or winter scenario, producers will want to supplement at as high levels as possible,” he said.

“And even though this research is conducted with stocker calves, I think there is opportunity for cow/calf producers to utilize the distiller's grains as well,” MacDonald said. “The supplemental fat has shown to improve reproduction, as well as providing energy to maintain or improve body condition score.”

However, potential dangers exist if animals are fed at extreme rates due to fat and sulfur content, he said. Excessive fat can reduce forage digestibility. Also, sulfur can tie up minerals such as copper, creating a deficiency. Excessive sulfur may cause polioencephalomalacia, also known as “brainers.”

Producers who use distiller's grains need to be cognizant of all sulfur sources, including water, MacDonald said. If a producer is feeding distiller's grains high in sulfur and also have sulfur in their water, it could be enough to cause trouble.

The supplementation trials were only the first step in MacDonald's study, he said.

Comparisons of distiller's grains to more traditional supplementation and following the calves onto wheat pasture need to done, he said.

“I'm very much enthused about using distiller's grains to produce more beef on a fixed-land base,” he said. “The caveat will be to see what previous supplementation does to subsequent wheat grazing gains. We'll have some data on that in the spring.”

Media Contact

Dr. Jim MacDonald EurekAlert!

More Information:

http://www.tamu.edu

All latest news from the category: Agricultural and Forestry Science

Back to home

Comments (0)

Write a comment

Newest articles

Lighting up the future

New multidisciplinary research from the University of St Andrews could lead to more efficient televisions, computer screens and lighting. Researchers at the Organic Semiconductor Centre in the School of Physics and…

Researchers crack sugarcane’s complex genetic code

Sweet success: Scientists created a highly accurate reference genome for one of the most important modern crops and found a rare example of how genes confer disease resistance in plants….

Evolution of the most powerful ocean current on Earth

The Antarctic Circumpolar Current plays an important part in global overturning circulation, the exchange of heat and CO2 between the ocean and atmosphere, and the stability of Antarctica’s ice sheets….

Partners & Sponsors