Composting may be alternative in wake of horse slaughter bill

Composting may be an environmentally friendly option that fits in the “circle of life” frame of mind and may be less emotional, two area researchers said.

On Sept. 7 the House approved the Act, which bans the slaughter of horses for human consumption by a vote of 263-146. The Senate has yet to schedule the issue for consideration.

Approximately 90,000 horses, or 1 percent of the U.S. horse population, is slaughtered annually, said Dr. Lance Baker, West Texas A&M University associate professor of animal science.

“If they don't go to slaughter, they will have to go somewhere else,” Baker said.

The options for dealing with a carcass are burial, rendering, landfill disposal, incineration, composting or bio-digesting, he said. Many of these are costly, and a horse owner often has to pay to put the horse down and for its disposal, instead of getting money for the animal.

Large-carcass composting is a growing and accepted practice among feedyards and dairies, said Dr. Brent Auvermann, a Texas Agricultural Experiment Station agricultural engineer who has researched the process for about five years.

“Since we had already done some work with dairy cattle, which weigh about 1,400 pounds, a quarter horse at 1,000 pounds wasn't much different,” Auvermann said. “The main thing is: the larger the carcass, the higher the stakes. It is critical that whoever does it, does it right.”

Auvermann, Baker and West Texas A&M graduate student Laurie Brown began conducting a composting trial on horses last winter, using dead horses that would otherwise have gone to the landfill. The horses were provided by area veterinarians .

The trial tested three different “recipes” of composting material designed by Auvermann: 100 percent stall cleanout (horse manure and bedding); 50 percent cattle manure and 50 percent waste hay; and 50 percent stall cleanout and 50 percent cattle manure. He said he prefers the two mixes to the 100 percent stall cleanout.

Large animal composting works best if pre-composting of the material has already been started before the carcass is added, Auvermann said. The carcass is laid on a bed of chopped hay and then covered completely with the composting material.

From that point, moisture is a key, Auvermann and Baker said. Auvermann said it would be better to err on the side of too dry than too wet.

“Add water until a handful of the mixture squeezed hard doesn't result in droplets of water, but does leave a sheen of water on the glove,” he said.

A good indication the composting process is working correctly is temperature, Auvermann said. The temperature should start rising within 12 to 24 hours and reach a level between 131 degrees Fahrenheit and 155 degrees Fahrenheit and stay in that range for several weeks to a month.

The temperature should be taken with at least a 48-inch temperature probe and taken in several locations throughout the pile, he said.

In the studies, the pile was turned at three months, at which time Baker said only a few large bones were identifiable. By six months, nothing was identifiable.

The optimum time to wait before making the first turn with larger animals is five to six months, Auvermann said. A large carcass will take from seven to nine months to compost completely, at which point it can be used as a fertilizer on agricultural ground.

The phosphorous level will be about 20 to 25 pounds per dry ton. It will have some nitrogen, but might contain less than 20 pounds per dry ton or, if the recipe is right, up to 35 pounds per dry ton, he said.

“This is well suited to cotton in terms of the nitrogen-phosphorous ratio,” Auvermann said, adding cotton gin trash would be an excellent ingredient to put into the composting mix.

The compost must go through three phases before it is a valuable product, he said. The final phase, curing, is important because it lets the last intermediate compounds be converted to non-phytotoxic compounds.

“Maturity testing is a good idea,” Auvermann said. “When you put compost on plants, if it is not mature, it may compete with the plants for nitrogen. It also can kill the plant if it is too hot with phytotoxic compounds.”

He suggested trying a small amount with potting soil in a seeding tray to see if the seed would germinate and grow, or using a maturity test kit.

Auvermann said several other options for the composted material would be to be used as a Class A biosolid for roadways and to help establish turf grass, or it could be used in the bioenergy arena. The material could be gasified and burned after it is composted.

Both Auvermann and Baker said the small individual horse owner might not see composting as an option, but a large, centrally located commercial composting operation would offer a service to area horse owners and veterinarians.

“Without renderers to go to, this could become a big market,” Baker said. “If you look at it environmentally and politically, it works. It's the whole circle of life thing. You grow the grass to feed the animals and then turn around and use them to do the same thing for the next generation.”

Media Contact

Dr. Brent Auvermann EurekAlert!

More Information:

http://www.tamu.edu

All latest news from the category: Agricultural and Forestry Science

Back to home

Comments (0)

Write a comment

Newest articles

Lighting up the future

New multidisciplinary research from the University of St Andrews could lead to more efficient televisions, computer screens and lighting. Researchers at the Organic Semiconductor Centre in the School of Physics and…

Researchers crack sugarcane’s complex genetic code

Sweet success: Scientists created a highly accurate reference genome for one of the most important modern crops and found a rare example of how genes confer disease resistance in plants….

Evolution of the most powerful ocean current on Earth

The Antarctic Circumpolar Current plays an important part in global overturning circulation, the exchange of heat and CO2 between the ocean and atmosphere, and the stability of Antarctica’s ice sheets….

Partners & Sponsors