Forum for Science, Industry and Business

Sponsored by:     3M 
Search our Site:

 

Increased clumsiness in former welders

07.02.2012
Welders who are exposed to manganese from welding fumes, risk developing increased clumsiness – and the result may remain decades after exposure has ceased. This is the finding of a study at the University of Gothenburg, Sweden, of former shipyard workers.
It is estimated that 35,000 people in Sweden work full-time with welding, while many more carry out welding as one of several workplace activities. Previous research has shown that the concentration of manganese in the air during welding often lies at levels that can give immediate negative effects on the central nervous system, but the long-term effects of exposure to manganese have been essentially unexplored.

Effects on fine motor skills
Scientists at the Sahlgrenska Academy, University of Gothenburg, have now shown in a study of former shipyard workers in Gothenburg that long-term exposure to manganese can give permanent effects on fine motor skills almost 20 years after the exposure has ceased.

Test on Gothenburg welders
Scientist Gunilla Wastensson of the Department of Occupational and Environmental Medicine at the Sahlgrenska Academy has examined 17 former shipyard welders who worked at the shipyards in Gothenburg. The average period that had passed since they stopped welding was 18 years. The average period during which the participants had worked with welding was 28 years. They were given several tests to measure manual dexterity and motor speed, eye-hand coordination, tremor and balance. Their test results were compared to 21 other shipyard workers who had worked with other tasks, such as filers and electricians.

Total individual mangan exposure
The investigation showed that shipyard welders performed less well than the other shipyard workers in a test of manual dexterity and motor speed. The scientists also calculated a measure of total manganese exposure for each individual.
“The investigation showed that individuals with higher total manganese exposure had a poorer performance. We interpret this as a possible remaining effect of previous exposure to manganese, which is remarkable, given that so long a period had passed since they stopped welding”, says Gunilla Wastensson.

First study of long-term effects
The study is the first to examine the effects a considerable period after the exposure to manganese has ceased. The results are worrying, but Gunilla Wastensson emphasises that they must be confirmed in further studies.
“Recent improvements in the work environment mean that the levels are lower now, but further measures to improve the situation associated with exposure to manganese at work are important”, she says.

MANGANESE
Manganese is a metal that occurs naturally in the environment and in our bodies, where it is important in processes such as the turnover of carbohydrates and fats. People who are occupationally exposed for long periods to dust and fumes that contain high concentrations of manganese run the risk of developing, in rare cases, manganism. This is a disease with symptoms similar to those of Parkinson disease. It is caused by an accumulation of manganese in particular regions of the brain known as the basal ganglia, which are important for controlling body movement. Manganese is slowly excreted once exposure to the metal ends. The threshold limit value for manganese in air has been severely reduced in recent years, and is now 0.2 mg/m3 for total dust, and 0.1 mg/m3 for respirable dust. There is, however, a serious risk that the threshold limit value for manganese is exceeded at many welding locations. A proposal has been put forward in the US to reduce the threshold limit value to 0.02 mg/m3.

For more information, please contact: Dr. Gunilla Wastensson, at the Sahlgrenska Academy, University of Gothenburg and senior consultant at the Sahlgrenska University Hospital
Tel: +46 31 786 2894

E-mail: gunilla.wastensson@amm.gu.se

Helena Aaberg | idw
Further information:
http://www.gu.se

More articles from Studies and Analyses:

nachricht Some brain tumors may respond to immunotherapy, new study suggests
11.12.2018 | Columbia University Irving Medical Center

nachricht Climate change and air pollution damaging health and causing millions of premature deaths
30.11.2018 | International Institute for Applied Systems Analysis (IIASA)

All articles from Studies and Analyses >>>

The most recent press releases about innovation >>>

Die letzten 5 Focus-News des innovations-reports im Überblick:

Im Focus: Data use draining your battery? Tiny device to speed up memory while also saving power

The more objects we make "smart," from watches to entire buildings, the greater the need for these devices to store and retrieve massive amounts of data quickly without consuming too much power.

Millions of new memory cells could be part of a computer chip and provide that speed and energy savings, thanks to the discovery of a previously unobserved...

Im Focus: An energy-efficient way to stay warm: Sew high-tech heating patches to your clothes

Personal patches could reduce energy waste in buildings, Rutgers-led study says

What if, instead of turning up the thermostat, you could warm up with high-tech, flexible patches sewn into your clothes - while significantly reducing your...

Im Focus: Lethal combination: Drug cocktail turns off the juice to cancer cells

A widely used diabetes medication combined with an antihypertensive drug specifically inhibits tumor growth – this was discovered by researchers from the University of Basel’s Biozentrum two years ago. In a follow-up study, recently published in “Cell Reports”, the scientists report that this drug cocktail induces cancer cell death by switching off their energy supply.

The widely used anti-diabetes drug metformin not only reduces blood sugar but also has an anti-cancer effect. However, the metformin dose commonly used in the...

Im Focus: New Foldable Drone Flies through Narrow Holes in Rescue Missions

A research team from the University of Zurich has developed a new drone that can retract its propeller arms in flight and make itself small to fit through narrow gaps and holes. This is particularly useful when searching for victims of natural disasters.

Inspecting a damaged building after an earthquake or during a fire is exactly the kind of job that human rescuers would like drones to do for them. A flying...

Im Focus: Topological material switched off and on for the first time

Key advance for future topological transistors

Over the last decade, there has been much excitement about the discovery, recognised by the Nobel Prize in Physics only two years ago, that there are two types...

All Focus news of the innovation-report >>>

Anzeige

Anzeige

VideoLinks
Industry & Economy
Event News

ICTM Conference 2019: Digitization emerges as an engineering trend for turbomachinery construction

12.12.2018 | Event News

New Plastics Economy Investor Forum - Meeting Point for Innovations

10.12.2018 | Event News

EGU 2019 meeting: Media registration now open

06.12.2018 | Event News

 
Latest News

Data use draining your battery? Tiny device to speed up memory while also saving power

14.12.2018 | Power and Electrical Engineering

Tangled magnetic fields power cosmic particle accelerators

14.12.2018 | Physics and Astronomy

In search of missing worlds, Hubble finds a fast evaporating exoplanet

14.12.2018 | Physics and Astronomy

VideoLinks
Science & Research
Overview of more VideoLinks >>>