Home Reports Health and Medicine Content

Beware of Washing Away the Pathogens and Sending Them to the Food

next article

13.08.2009

Research at Kansas State University's Food safety Consortium shows that without proper precautions, washing the floor drains in food processing plants could actually make it easier for any Listeria monocytogenes to travel from the drain to points on the processing line.

When it’s time to wash down the facilities in food processing plants to clear out any pathogenic bacteria, industry needs to watch for one unintended consequence. Washing the floor drains could actually make it easier for any Listeria monocytogenes to travel from the drain to points on the processing line.

Food Safety Consortium researchers at Kansas State University already knew that the open floor drains in processing environments can harbor the bacteria, which is why those drains are the targets of high pressure washing and cleaning. They found out a new angle: that the aerosols generated by the washing can transfer the bacterial cells away from the drain as intended but onto surfaces where food is being processed a few feet above the floor.

The situation can be remedied, but workers need to be trained how to do so, said Jasdeep Saini, a KSU doctoral student in food science who researched the issue with food science professors James Marsden and Daniel Fung. The workers would then modify their cleaning procedures.

“If the worker who is actually doing that knows that this is the point from where the translocation of bacteria is actually occurring and is told to be careful, some change in that respect can be made,” Saini said.

The research team ran tests to find out the potential for translocating L. monocytogenes from drains to food contact surfaces. The researchers placed stainless steel markers at heights of 1, 3 and 5 feet above the drain level. They checked the markers after using a high-pressure hose to wash the drain and took samples after eight hours and again after 48 hours.

The numbers for both the eight-hour and 48-hour tests showed that bacterial cells from the drain were found at all three height levels, the highest number at the 1-foot level closest to the drain. More bacterial cells were present on the contact surfaces after 48 hours than after eight hours, likely because of the longer time available for the cells to proliferate and form a biofilm – thin, resistant layers of microorganisms – as protection against environmental stress.

“Listeria has been known to form bioflilms,” Saini said. “Biofilms develop between 36 and 48 hours. If there are biofilms existing in the drain, how those are actually translocated can cause contamination on the line.”

Dave Edmark | Source: Newswise Science News
Further information: www.uark.edu
www.ksu.edu

next article