In addition to super stain-resistant clothes, the coating could lead to breathable garments to protect soldiers and scientists from chemicals, and advanced waterproof paints that dramatically reduce drag on ships.
Droplets of solutions that would normally damage either your shirt or your skin recoil when they touch the new "superomniphobic surface."
"Virtually any liquid you throw on it bounces right off without wetting it. For many of the other similar coatings, very low surface tension liquids such as oils, alcohols, organic acids, organic bases and solvents stick to them and they could start to diffuse through and that's not what you want," said Anish Tuteja, assistant professor of materials science and engineering, chemical engineering and macromolecular science and engineering.
Tuteja is the corresponding author of a paper on the coating published in the current issue of the Journal of the American Chemical Society.
She and her colleagues tested more than 100 liquids and found only two that were able to penetrate the coating. They were chlorofluorocarbons—chemicals used in refrigerators and air conditioners. In Tuteja's lab, in a demonstration, the surface repelled coffee, soy sauce and vegetable oil, as well as toxic hydrochloric and sulfuric acids that could burn skin. Tuteja says it's also resistant to gasoline and various alcohols.
To apply the coating, the researchers use a technique called electrospinning that uses an electric charge to create fine particles of solid from a liquid solution. So far, they've coated small tiles of screen and postage-stamp-sized swaths of fabric.
The coating is a mixture of rubbery plastic particles of "polydimethylsiloxane," or PDMS, and liquid-resisting nanoscale cubes developed by the Air Force that contain carbon, fluorine, silicon and oxygen. The material's chemistry is important, but so is its texture. It hugs the pore structure of whatever surface it's being applied to, and it also creates a finer web within those pores. This structure means that between 95 and 99 percent of the coating is actually air pockets, so any liquid that comes in contact with the coating is barely touching a solid surface.
Because the liquid touches mere filaments of the solid surface, as opposed to a greater area, the developed coating can dramatically reduce the intermolecular forces that normally draw the two states of matter together. These Van der Waals interaction forces are kept at a minimum.
"Normally, when the two materials get close, they imbue a small positive or negative charge on each other, and as soon as the liquid comes in contact with the solid surface it will start to spread," Tuteja said. "We've drastically reduced the interaction between the surface and the droplet."
With almost no incentive to spread, the droplets stay intact, interacting only with molecules of themselves, maintaining a spherical shape, and literally bouncing off the coating.
One classification of liquid that this coating repels is the so-called non-Newtonian category, which includes shampoos, custards, blood, paints, clays and printer inks, for example. These are liquids that change their viscosity depending on the forces applied to them. They differ from the Newtonians, such as water and most other liquids, whose viscosity stays the same no matter the force applied. Viscosity is a measure of a liquid's resistance to flow on the application of force, and it's sometimes thought of as its thickness.
"No one's ever demonstrated the bouncing of low surface tension non-Newtonian liquids," Tuteja said.
The paper is titled "Superomniphobic Surfaces for Effective Chemical Shielding." Doctoral student Shuaijun Pan and postdoctoral researcher Arun Kota, both in materials science and engineering, are the first authors of the paper. Also contributing is Joseph Mabry, in the rocket propulsion division of the Air Force Research Laboratory. The work is funded by the Air Force Office of Scientific Research.
Anish Tuteja: www.mse.engin.umich.edu/people/faculty/tuteja
Abstract of paper: http://pubs.acs.org/doi/abs/10.1021/ja310517s
EDITORS: Watch and link to a video about the new repellent surface at www.youtube.com/watch?v=ICw5k1tDZSk. Photos are available at www.flickr.com/photos/michigan-engineering/sets/72157632483361482
Nicole Casal Moore | Source: Newswise
Further information: www.umich.edu
Further Reports about: air conditioner > Ambient Air > chemical engineering > drag on ships > Materials Science > polydimethylsiloxane > similar coatings > super stain-resistant clothes > surface tension > toxic hydrochloric and sulfuric acids > waterproof paints > Wet Circuits
More articles from Materials Sciences:
Stacking 2-D materials produces surprising results
17.05.2013 | Massachusetts Institute of Technology
Engineered biomaterial could improve success of medical implants
15.05.2013 | University of Washington
Researchers have shown that, by using global positioning systems (GPS) to measure ground deformation caused by a large underwater earthquake, they can provide accurate warning of the resulting tsunami in just a few minutes after the earthquake onset.
For the devastating Japan 2011 event, the team reveals that the analysis of the GPS data and issue of a detailed tsunami alert would have taken no more than three minutes. The results are published on 17 May in Natural Hazards and Earth System Sciences, an open access journal of ...
A new study of glaciers worldwide using observations from two NASA satellites has helped resolve differences in estimates of how fast glaciers are disappearing and contributing to sea level rise.
The new research found glaciers outside of the Greenland and Antarctic ice sheets, repositories of 1 percent of all land ice, lost an average of 571 trillion pounds (259 trillion kilograms) of mass every year during the six-year study period, making the oceans rise 0.03 inches (0.7 mm) per year. ...
About 99% of the world’s land ice is stored in the huge ice sheets of Antarctica and Greenland, while only 1% is contained in glaciers.
However, the meltwater of glaciers contributed almost as much to the rise in sea level in the period 2003 to 2009 as the two ice sheets: about one third. This is one of the results of an international study with the involvement of geographers from the University of Zurich.
Second sound is a quantum mechanical phenomenon, which has been observed only in superfluid helium.
Physicists from the University of Innsbruck, Austria, in collaboration with colleagues from the University of Trento, Italy, have now proven the propagation of such a temperature wave in a quantum gas. The scientists have published their historic findings in the journal Nature.
Below a critical temperature, certain fluids become superfluid ...
Researchers use synthetic silicate to stimulate stem cells into bone cells
In new research published online May 13, 2013 in Advanced Materials, researchers from Brigham and Women's Hospital (BWH) are the first to report that synthetic silicate nanoplatelets (also known as layered clay) can induce stem cells to become bone cells without the need of additional bone-inducing factors.
Synthetic silicates are made ...
17.05.2013 | Physics and Astronomy
17.05.2013 | Physics and Astronomy
17.05.2013 | Physics and Astronomy
17.05.2013 | Event News
15.05.2013 | Event News
08.05.2013 | Event News